is part of the Division of Informa PLC

This site is operated by a business or businesses owned by Informa PLC and all copyright resides with them. Informa PLC's registered office is 5 Howick Place, London SW1P 1WG. Registered in England and Wales. Number 8860726.

Serving: IA
Flooded Grain And Other Harvest Issues Haunt Some Farmers

Flooded Grain And Other Harvest Issues Haunt Some Farmers

Issues stemming from the unusual weather patterns of this past summer have surfaced at harvest. Grain that was submerged (water over the ears) in floodwater in fields is considered contaminated and isn't eligible for entry into the food or feed markets

Harvest 2010 is well underway and a few issues stemming from the unusual weather patterns last summer are coming up. Here's a special report issued this week by Iowa State University Extension specialists. ISU grain quality expert Charles Hurburgh, corn agronomist Roger Elmore and plant pathologist Alison Robertson provide the following information.

What is the official definition of flooded grain?

Examples of submerged grain.

On September 30 the Iowa Department of Agriculture and Land Stewardship (IDALS), as the state representative for the U.S. Food and Drug Administration, issued a statement saying that grain submerged (over the grain) in flood waters is to be considered contaminated and therefore not eligible for entry into food-feed markets.

Ethanol is a feed market because of the dried distillers grains with solubles (DDGS). This is the same policy that was used for grain in storage that was submerged in 2008 by the eastern Iowa floods. The logic is that, in addition to in-field mold issues (see example below), flood waters can contain many contaminants from a wide variety of sources.
The release and accompanying public health fact sheet are posted on the Iowa Grain Quality Initiative website. Take safety precautions when knocking this corn down; do not run it through a combine or use a stalk shredder – doing so would increase fugitive dust even more. The IDALS/FDA statement allows insurance adjusters to consider the grain of no value in the crop insurance process. In the future, weather challenges may continue to create food safety situations; you should expect that grain will be considered in the same way as any other food ingredient as efforts to maintain food safety increase.

Other 2010 harvest issues: cool grain immediately after harvest

Both corn and soybeans are being harvested in warm weather this year. Be sure to cool the grain immediately after harvest to prevent spoilage from starting, even in the relatively drier grain this year. The dew point is a good indication of cooling potential; lately dew points have been in the 40s and 50s even with temperatures in the 70s and above. Low humidity air has good cooling potential as it evaporates water from grain. 

Soybeans are particularly at risk because we tend to think of them as safe for storage when they are harvested below 13% moisture, and therefore sometimes put them in non-aerated or poorly aerated storages. If unaerated storage must be used, only put cool, dry grain in there.

The plant diseases that affected corn and soybeans this year may not have a large effect on grain quality, other than seed size and fill. However, stalk rots are common and lodged corn may require early harvest even though the warm weather could produce more in-field drydown.  Again this creates the need to pay attention to grain temperatures while in storage and incorporate extra cooling cycles. In 2009, the common practice of storing moderate moisture corn without drying (up to 19%) did not work well because the overall corn storage quality was poor; this year the risk is warm corn starting to spoil if not cooled.
A lot of the corn this year ran out of nitrogen during the latter part of the growing season. Too much rain simply washed the nitrogen away or out of reach by plant roots. Nitrogen deficient corn will likely have lower protein content in the grain. Early indications are that soybean protein and oil will be good, approximately at the long term averages of 35% protein and 19% oil.

An important reminder - don't commingle 2009 and 2010 corn

Reminder:  Corn from different crop years should never be mixed in storage. Instability of the grain will result. With the large amount of the poorer quality 2009 corn still in storage, grain will be blended when sold, but this should not be done before storage.

Use test weight as a guide to determine which 2010 grain should be kept and which should be marketed or used quickly. Corn less than 54 lbs. per bushel will have progressively poorer storage properties; likewise heavier corn will have better storage properties. With the large amount of damaged corn in storage from 2009, the market cannot accept more condition problems from 2010 corn.

Hide comments


  • Allowed HTML tags: <em> <strong> <blockquote> <br> <p>

Plain text

  • No HTML tags allowed.
  • Web page addresses and e-mail addresses turn into links automatically.
  • Lines and paragraphs break automatically.