Farm Progress is part of the Informa Markets Division of Informa PLC

This site is operated by a business or businesses owned by Informa PLC and all copyright resides with them. Informa PLC's registered office is 5 Howick Place, London SW1P 1WG. Registered in England and Wales. Number 8860726.

Serving: Central

Ginners ask for bale rule revision

The Southern Cotton Ginners Association, terming the action “disturbing,” has called on the exchange to reverse a recent decision that requires an increase in bale weights in order to avoid penalties.

The revision to the exchange’s Rule 19 - which the SCGA says was implemented without a review period or input from other segments of the cotton industry as to its feasibility - became effective on all invoices after Aug. 1.

In a letter to the exchange, Sledge Taylor, Como, Miss. ginner/producer and SCGA president, said it “will cause undue hardship for ginners and producers, who are currently facing enough economic pressures without this added burden.”

The Rule 19 changes provide that cotton bales weighing less than 474 pounds net must be penalized as follows:

  • For each bale weighing less than 474 pounds, but not under 440 pounds, a $3 penalty.
  • For each bale weighing less than 440 pounds, but not under 410 pounds, a $6 penalty.
  • Bales weighing less than 410 pounds may be rejected - but if accepted, must be penalized $20 per bale.
  • An exception to these penalties is made where any invoice averages 490 pounds or more, in which case there will be no penalty, but bales weighing less than 410 pounds may be rejected.
  • Bales weighing more than 600 pounds net may be rejected.

In addition to the financial considerations, the Rule 19 changes would have other adverse impacts, the SCGA letter noted.

“To increase the bale weight is just not as simple as making a few adjustments to the bale press,” Taylor noted. Some of the problems the new weight requirements would cause:

  • In modern high capacity gins, it is more difficult to adjust relatively small increments of weight to the bale at the press. If a gin with bales averaging 488 pounds were to increase bale size to avoid penalties, they would be faced with many bales in the 538 pound range because another complete tramper stroke would have to be added and high speed gins commonly charge the press with as much as 50 pounds per stroke

    “Many presses cannot press a bale that size, especially if the cotton is dry,” Taylor pointed out. “The gin will obviously be unable to comply.”

  • Additional required pressure at the press will cause increased wear in ginning equipment, and some presses may be unable to handle the pressure required.
  • Higher ginning costs as a result of the increased power requirements to pack a heavier bale.
  • In some instances, a variance of several pounds in bale weight is due to moisture content (or lack thereof), and other cotton quality factors not fully controllable at the gin.
  • Increased pressure on the bale ties will result in more tie failures and potential injury to workers.
  • The effective date of the rule change affects last year’s crop, and at the time those bales were ginned there was no knowledge of the impending changes in the rules.

“Bale size is very much a factor of the working pressure at the press and the moisture content of the cotton,” Taylor noted. “I’m not sure Rule 19 will have the intended effect of increasing average bale weights, since that is related to the science of physics and not some arbitrary rule.”

A review of gin bale weights from 1994-2001 shows that the trend for the nation as a whole was flat, Taylor says.

In the Mid-South, “They have been remarkably constant over the eight-year period. Missouri weights have trended up, but they started a bit lower than other states. Tennessee and Louisiana trended up slightly over the period, while Arkansas and Mississippi trended down.

“My conclusion is that there is no trend toward lower bale weights that would cause the merchants to have a legitimate concern for encouraging higher weights.”

In Arkansas for 2001, the average bale weight was 488 pounds; in Louisiana 489 pounds; in Mississippi 488.1 pounds; in Missouri 489 pounds; and in Tennessee 491.6 pounds.

Nationally, over the eight-years, bale weights averaged 491.6 pounds on the low side and 493.4 pounds on the high side.

Producers and ginners have been experiencing “one of the most trying times in the cotton economy,” he said, “and for the good of the industry, now is not the time to increase the penalty burden.

“On behalf of our affiliate associations in Arkansas, Mississippi, Louisiana, Missouri, and Tennessee, I ask that you reverse these changes to Rule 19.”


Hide comments


  • Allowed HTML tags: <em> <strong> <blockquote> <br> <p>

Plain text

  • No HTML tags allowed.
  • Web page addresses and e-mail addresses turn into links automatically.
  • Lines and paragraphs break automatically.